DYNAMICS SPC representatives delivered reports at the regional scientific-practical conference "Science, education, business"
The annual conference "Science, education and business" was held on 6th of May, 2014, at the Institute of Radio electronics, Service and Diagnostics (IRESD), in Omsk, traditionally for the 10th time.
At the plenary session, A.P. Naumenko, PhD of Technical Sciences, Professor presented a report on the topic titled "Vibroacoustic diagnostics as a basis of condition monitoring".
Within section № 4 entitled "New results of fundamental and applied science" in the "Results of scientific research" subsection the following research fellows delivered their presentations:
A.V. Zaitsev with the report titled "Improving the reliability of diagnostics of wheel-motor blocks' axle equipment of EMU-trains";
V.V. Basakin with the report titled "The examination of the dependence of the bearing vibration parameters on axial and radial loads".
In the conference E.A. Burda gave a poster presentation on the topic "The research on the applicability of the partial discharges' parameters measurement method for the diagnostics of an isolation state of a stator of an asynchronous motor with operating voltage of 380 V".
According to the conference results all our representatives` presentations were awarded by the honorary diplomas.
DYNAMICS SPC took part in the conference of "Pump-and-compressor equipment" network group of "SIBUR", LLC
The conference was held on April 21-22, 2014, by "Tobolsk-Polymer", LLC.
More than 25 representatives of the chief mechanics departments of the "SIBUR holding", JSC, within the basic polymers directorate , participated in the conference, as well as the representatives of enterprises realizing the equipment supply for the "SIBUR holding", JSC.
"Tobolsk-Polymer", LLC is a polypropylene production enterprise with a capacity of 500 thousand tons per year, it`s the top three of the world's production in this segment. Polypropylene is a third plastic in a world by consumption criteria after polyethylene and PVC.
PhD. in technical Sciences, Professor, the Systems Support and Promotion Department representative A.P. Naumenko presented a report "Improving the reliability and operating efficiency of petrochemical complexes based on the technology of safe resource-saving equipment operation" on behalf of DYNAMICS SPC at the conference.
DYNAMICS SPC took part in the XX all-Russian Scientific and technical conference on non-destructive testing and technical diagnostics with international participation
The XX all-Russian Scientific and technical conference on non-destructive testing and technical diagnostics with international participation was held on the territory of Expocentre on Krasnaya Presna (Moscow) on 3-6 of March, 2014, simultaneously with the Exhibition of equipments and technologies of non-destructive testing "NDT Territory". It is the largest event in Europe, the main event in the Russian Federation, held every three years. The event was held under the aegis of the Russian association of non-destructive testing and technical diagnostics (RONKTD).
At the conference the top scientists and specialists from Russia, CIS and far abroad gathered to discuss current trends in the field of non-destructive testing.
More than 90 top Russian and foreign companies took part in the conference, among them are the national society of non-destructive testing of Germany, the Czech Republic, Bulgaria, Ukraine, Moldova, Belarus, Kazakhstan, Georgia, Latvia and other countries. The 229 reports in 12 conference sections were presented to the participants of the conference.
DYNAMICS SPC delivered its reports in the section № 8, titled "Vibration analysis" (section leaders: Zusman G.V, Kostyukov V.N.) and in the section № 7, titled "Methods of non-destructive testing and technical diagnostics of residual life" (section leaders: Makhutov N.A., Vengrinovich V.L., Matveev V.I.).
The presentations were made by:
The Director General of DYNAMICS SPC, Doctor of Technical Sciences, Professor V.N. Kostyukov. – "Vibration diagnostic monitoring of equipment of production and transport complex".
Deputy Director General on science, Candidate of Technical Science S.N. Boychenko – "The operating of the Hurst fractal dimension coefficient for vibration diagnostics of the rotary pump unit health", "The fiber-optic system for monitoring of temperature and deformation of a tank".
Head of technical support and promotion of the systems department, Doctor of Technical Sciences, Professor A.P. Naumenko – "Basic principles of diagnostics and monitoring of piston machines in real time".
Research fellow A.E. Tsurpal – "Examination of vibrational activity of rail rolling stock mechanical parts assemblies".
Research fellow A.V. Zaitsev – "Improving the reliability of the rotary units diagnostics".
All reports were listened with a great interest and attention.
The article about the Director General of DYNAMICS SPC Kostyukov V.N. has been published in the "Business Elite of Russia" almanac.
The article about the Director General of DYNAMICS SPC, Doctor of Technical Sciences, Professor, the of RF Government prize-winner Kostyukov Vladimir Nikolaevich has been published in the "Business Elite of Russia ("Delovaya Elita Rossii")" almanac.
The beginning of the XXI century was marked by the formation of a new Russia image, the formation of a positive image of the country in the international arena.
The confident integration of Russia into the world community depends largely on the dynamic development of business entities.
The positive changes, which are happening in Russia, largely determine the success of the companies' domestic business, which is shown in the literary and biographical almanac "Business Elite of Russia".
DYNAMICS SPC participated in the seminar on "Improving the reliability of pump equipment. Analysis of existing pump systems. Basic conceptions of design and choice of pump equipment for oil-refining and petrochemical plants"
Seminar was held on 18-21 of February, 2014, in Bekasovo village, Moscow Region. The event was carried out by the decision of the Council of Chief Mechanics of Russia and CIS countries refineries and petrochemical plants, "STC of the Council of Chief Mechanics", LLC with the participation of the Association of oil-refiners and petrochemists.
More than 30 papers and reports by Russian and foreign companies concerning pump equipment reliability, the new achievements in the field of design and manufacture of pump equipment, operation and maintenance of pump equipment for oil-refining and petrochemical plants were presented to the chief mechanical specialists.
The report of "Volgogradneftemash", JSC representative Shelestov D.S. "The construction modernization of pump units taking into account the requirements of ISO 13709/API 610, TC of major oil companies" gives positive characteristic of the system COMPACS®-RPG, which is used in the enterprises for the examination carrying out during the development and testing of new pump units and their assemblage final check.
Sales manager Tkachenko A.A. attended the seminar on behalf of DYNAMICS SPC and delivered the report entitled "The concept of choice and justification of the characteristics of the pump equipment monitoring system". The report aroused a great interest as among the representatives of enterprises, using the system for automatic diagnostics and vibration analysis, and comprehensive condition monitoring of equipment COMPACS®, so among the representatives of other plants and commercial companies.
DYNAMICS SPC took part in the XVII annual round table "The refining and petrochemicals in Russia and CIS countries" and in the III school-seminar "The industrial risks assessment and management in the field of manufacturing safety"
XVII annual roundtable "The refining and petrochemicals in Russia and CIS" took place in Pullman Royal Casino hotel, Cannes, France within the framework of refining and petrochemicals week in CIS 3-5 of December, 2013.
First Deputy of the Director General of DYNAMICS SPC Kostyukov Andrey Vladimirovich took part in the roundtable. He made a presentation entitled "The manufacturing safety risk monitoring in real time", in which he touched upon the issues of using the latest software for maximum efficiency repairs.
Also A.V. Kostyukov participated in the III school-seminar "The assessment and management of industrial risks in manufacturing safety. "The risks monitoring of complex and unique units", held on 10-13 of December, 2013 in Moscow Park-hotel "Solnechny". This school-seminar concentrates on the issues of analysis, assessment and monitoring of hazardous production facilities and complex technical systems. Andrey Vladimirovich delivered two presentations: "The assessment of safe petrochemical complex units operation reliability" and "The manufacturing safety risk monitoring in real time", which aroused a great interest of the participants.
The articles by V.N. Kostyukov and A.P. Naumenko have been published in the "Mashinostroyenie" ("Engineering") encyclopedia v.IV-14
The articles of DYNAMICS SPC Director General, Doctor of Technical Sciences, professor, Russian Federation Government prize-winner Vladimir Nikolaevich Kostyukov and also the Head of system support and promotion department, Doctor of Technical Sciences Alexander Petrovich Naumenko were placed in the "Mashinostroyenie" v.IV-14:
Chapter 6.2. Technical diagnostics of engines - "The engines vibration analysis" (Kostyukov V.N., Naumenko A.P.);
Application. The engines quality as a basis for their competitiveness ensuring. "Improving the reliability of the piston machines, equipped with diagnostic and monitoring system (SDM)”. (Kostyukov V.N.).
The theory issues of workflows and internal-combustion engine modeling and also the design principles and basic assemblies and components calculations for the strength, rigidity and reliability were expounded in the Mashinostroyenie v.IV-14. Basic systems (power, control, boosting, cooling, lubricating, cleaning, start-up and reversing), methods, reducing the engines negative impact on the environment, were considered. There were indicated the characteristics of fuels (including the alternative ones), lubricants and coolants, testing and engines technical diagnostics methods. The encyclopedia reviewed cycles, design features and basic technical and economic indicators of modern engines, including non-traditional ones, and units. The principles of engines quality and competitiveness assurance were formulated.
COMPACS® systems became a winner of "Top 100 of Russian Goods - 2013" All-Russian Contest award!
A regional conference devoted to the World Quality Week was held in the building of the Government of Omsk region, on 27th of November, 2013. Within the framework of conference a solemn award of the winners of the federal stage of All-Russian Contest "Top 100 of Russian Goods - 2013" was held.
For the contest in the "Industrial and Technology Products" nomination were presented six commercially available products of DYNAMICS SPC, each of them passed all the qualifying stages of the contest:
System for automatic vibration analysis and monitoring of equipment COMPACS®, which provides safe, ecologically friendly and resource-saving operation of the equipment of explosive production, prevents accidents, operating faults and manages the condition of equipment by force of its continuous computer monitoring.
Comprehensive system for diagnostics of EMU-trains sections COMPACS®-EXPRESS-TR3, aims at comprehensive automatic assessment of condition of the most difficult and most subject to operational wear and failures equipment of EMU-trains sections (wheel-motor units, pantographs, pneumatic and electro-pneumatic equipment of brake system, electric control circuit, high-voltage power circuits, heating circuits and auxiliary machinery circuits), when carrying out the repairs of large volumes.
Stationary system for vibration analysis of wheel-motor units COMPACS®-EXPRESS, meant for the express health diagnostics of wheel-motor units (WMU) in a rolling stock.
On-board system for electric multiple-unit trains equipment health monitoring COMPACS®-EXPRESS-3, aims at electric multiple-unit train equipment real-time health monitoring. System allows to timely detect the occurrence and development of malfunctions with the data issuing on the display located in the driver's cabin.
Acoustic signal controller 2041 for acoustic emission monitoring of the COMPACS®-AE system, designed for the continuous monitoring and health evaluation of hazardous production facilities, such as coke drums, reactors, pipelines and other static equipment without decommissioning.
Diagnostic controller 2047 aims at operating as a part of computer monitoring automatic diagnostics COMPACS®.
The six products of SPC "Dynamics" mentioned above became the winners of the contest, and the following two of them became laureates:
Automatic vibration analysis and condition monitoring system COMPACS®.
Comprehensive system for diagnostics of EMU-trains sections COMPACS®-EXPRESS-TR3.
DYNAMICS SPC participated in the Conference of the Chief Mechanics of oil-refining and petrochemical enterprises from Russia and CIS countries held in "Volgogradneftemash" JSC
The Conference was held on 3-4 October, 2013. For the first time, "Volgogradneftemash", JSC arranged the conference of the chief engineers of petrochemical and refining enterprises, aimed at the demonstration of the enterprise’s capabilities in the field of the column tanks, vessels and pump equipment production. More than 40 mechanical service representatives of such companies as "Gazprom" JSC , "Rosneft" JSC, "Lukoil" JSC, "Bashneft" JSC and others took part in the conference.
Deputy Director General of Research, Candidate of Science, S.N. Boychenko and head of system`s advance and support department Doctor of Technical Science A.P. Naumenko participated in the conference on behalf of DYNAMICS SPC. They made a presentation about the Center`s recent development – COMPACS®-RPG system, made for test operation and pumps` final check carried out in "Volgogradneftemash" JSC.
The system consists of three areas allowing testing of three pumps` dimension types by automatic measurement of pump performance. The introduction of the system makes it possible for the enterprise to significantly improve the quality of produced pump units, as well as to adjust their constructions in order to increase safety and reliability.
The presentation of the COMPACS®-RPG system
The participants of the Chief Mechanics Conference - 2013
DYNAMICS SPC took part in the X International Exhibition on High-tech Equipment and Weapons "VTTV-Omsk-2013"
The exhibition was held on October 2-4, 2013 in Omsk Regional Exhibition Center.
The following product samples were presented by DYNAMICS SPC:
Diagnostic stations of the computer health monitoring system for machinery control and accidents prevention COMPACS®. Diagnostic stations are made in industrial and console versions.
Diagnostic controllers, which are designed for operation in the diagnostic stations. Controller of Acoustic Signals 2041 is used for acoustic-emission diagnostics within COMPACS®-AE system. Diagnostic Controller 2047 is aimed to work in the computer monitoring systems and automatic vibration analysis COMPACS®. Diagnostic controllers represent fanless failure-proof industrial computers developed by DYNAMICS SPC which perform the following functions: system management, measurement, archiving, analysis, visualization of measured parameters and reports of the expert system.
Vibration calibrator 8001, which is intended for the calibration of vibration-measuring equipment and vibration-measuring transducers in laboratory and industrial conditions.
The exhibition stands of DYNAMICS SPC were visited by huge number of professionals and business leaders of the Omsk city and other cities and countries. Design of stands and exhibits of DYNAMICS SPC was highly appreciated by the authorized representative of the Russian President in the Siberian Federal District V.A.Tolokonsky, Governor of the Omsk Region V.I. Nazarov, head of the Department of Russian Engineering Union in SFO G.G.Guselnikov and other guests of honor at the "VTTV-Omsk-2013" exhibition.
For the exhibiting the computer health monitoring system for machinery control and accidents prevention COMPACS® at "VTTV-Omsk-2013", DYNAMICS SPC was awarded with a gold medal and a diploma "For the development and introduction of new advanced technologies".
Executive Board of DYNAMICS SPC
and delegation of Omsk Region Governor
Stand of DYNAMICS SPC
in Petrochemical cluster
Stand of DYNAMICS SPC
in Exposition of Omsk Region